TheCropSite.com- news, features, articles and disease information for the crop industry

USDA GAIN: Oilseeds, Cotton, Sugar, Grain and Feed


03 April 2013

USDA GAIN: India Cotton and Products Annual 2013USDA GAIN: India Cotton and Products Annual 2013

India’s 2013/14 cotton production is forecast at 34.5 million 170 kg bales (26.9 million 480 lb bales /5.9 mmt) from 12 million hectares, the second highest area and production on record. Farmers have shown a strong preference for cotton in recent years and current market prices are already above the levels that informed planting decisions in 2011 and 2012.
USDA GAIN Report - Oilseeds, Cotton, Sugar, Grain and Feed

Exports are expected to reach 7.5 million 170 kg bales (5.8 million 480 lb bales/1.3 mmt), down from the increased 2012/13 estimate of 9.0 million 170 kg bales (7 million 480 lb bales/ 1.5 mmt). Much will depend on the import policies determined by China. Exports to smaller markets like Bangladesh and Vietnam are likely to account for half of the 2013/14 export forecast. India’s textile industry appears to be recovering from the losses and reduced borrowing limits that resulted from market volatility in 2011. The industry is on pace for record yarn exports; spinning margins, which have narrowed of late, have been robust for the past six months. With lower exports, adequate supply and hoped for improvement in global textile demand, cotton consumption is expected to expand to a record to a record 27.5 million 170 kg bales (21.5 million 480 lb bales/4.7 mmt), up 500,000 480 lb bales from the revised 2012/13 estimate.

Cotton

Production:

India’s 2013/14 cotton production is forecast at 34.5 million 170 kg bales (26.9 million 480 lb bales /5.9 mmt) from 12 million hectares, the second highest area and production on record. Farmers have shown a strong preference for cotton in recent years. In 2012/13, despite competitive prices for alternate crops, drier than average conditions in key cotton growing areas and a late start to the monsoon, farmers planted 11.8 million hectares, well above pre-season expectations. With stronger than expected exports in 2012/13 and robust domestic consumption, seed cotton prices are already 10 percent higher than the Rs. 4,500 per 100 kg (39 cents\lb) that informed farmers’ early season planting decisions in 2011/12 and 2012/13. Assuming that prices remain firm as new-crop planting approaches, farmers are expected to favor cotton over competing crops. Cotton’s relative drought tolerance also gives it an edge over competing crops as 65 percent of India’s cotton area is rain fed.

In 2012/13, Gujarat, India’s largest cotton producing state was affected by drier than average conditions, which led to a reduction in cotton acreage and production. While farmers have developed measures to conserve water in the state, principally through small “check” dams, rainfall was late and sparse enough to affect planting. Given Gujarat’s role as a key supplier of cotton to export markets and the adequate ginning capacity in the state, farmers are expected to increase 2013/14 planted area by more than 15 percent to 2.8 million hectares if monsoon rains cooperate. In Maharashtra, which accounts for more than 30 percent of India’s cotton plantings, area is expected to be largely unchanged from a year ago as farmers continue to view cotton as one of their best kharif (summer) planting options. Cotton area in Andhra Pradesh, India’s third largest cotton producing state was a record 2.2 million hectares in 2012/13. Area is expected to decline by more than 10 percent as farmers whose crops were affected by the late-season cyclone “Nilam” shift some of their cotton acreage to alternate crops like chilies, a crop less influenced by late-season rains. Area in the well-irrigated cotton areas in the northern states of Punjab, Haryana and Rajasthan is forecast unchanged from a year ago.

While yields have increased from an estimated 300 kg per hectare to nearly 500 kg per hectare over the past decade with the introduction of biotech seeds, better hybrids and expanded surface irrigation in some areas, there is concern within the industry that yields are stagnating or even declining. The increasing prevalence of “sucking insects” such as whitefly, the need for better micronutrient and fertilizer management, the spread of cotton into more drought prone areas and occasionally inconsistent seed quality are all cited as factors affecting yields. Despite these ongoing challenges, yields are forecast at 490 kg per hectare, up three percent from 2012/13 when erratic rains affected yields. India’s cotton yields continue to be significantly lower than the global average of 761 kg per hectare, a difference due, in part, to the relatively low plant populations that farmers deploy in order to create rows that are wide enough for bullocks to traverse. The advent of biotech cotton has helped to improve the predictability and stability of cotton as a crop which has supported the expansion of cotton area in recent years.

The Government of India has not announced the minimum support price (MSP) for the 2013/14 crop year. While prices vary by variety, the 2012/13 MSP for the most commonly traded staple length was increased 22 percent from Rs. 3,150 per 100 kg (27 cents\lb) of seed cotton to Rs. 3,850 per 100 kg (33 cents\lb). The higher MSP resulted in the Cotton Corporation of India (CCI) and other government agencies procuring 2.2 million 170 kg bales of cotton of which 2 million 170 kg bales are still in CCI stocks, much of it in Andhra Pradesh where farmers were affected by cyclone “Nilam” during harvest. Cotton prices have increased over the past month and the textile industry has pressured CCI to begin selling its stocks in the domestic market. Higher market prices should enable CCI and other government agencies to cover their costs when cotton sales begin.

It is difficult to predict the timing of the 2013/14 MSP announcement, some years the new prices are not announced until planting is nearly complete. However, two factors seem to point to the possibility of an increase. Currently, seed cotton prices are 25 percent higher than the MSP, if prices remain firm in the run up to planting, the MSP could be increased without exceeding prevailing market prices. Additionally, if government agencies are able to sell their 2012/13 stocks at a profit, officials may be more inclined to consider an MSP increase. The added price certainty of a higher MSP could prompt farmers to expand area beyond the forecast in this report; area reached 12.2 million hectares in 2011/12. Policy makers are approaching MSP levels that could lead to more regular market intervention by CCI and other government agencies if global market prices fall, a situation that would be further exacerbated if the weakened rupee begins to appreciate.

2012/13 planted area has been adjusted to 11.8 million hectares to better reflect official data. The production estimate is unchanged at 32.5 million 170 kg bales (25.5 million 480 lb bales / 5.5 mmt). The pace of cotton arrivals continues to lag the year ago pace. As of March 10, arrivals had reached 22.5 million 170 kg bales (17.6 million 480 lb bales / 3.8 mmt) compared to 23.7 million 170 kg bales (18.5 million 480 lb bales / 4.0 mmt) a year ago. Arrivals in Gujarat and Madhya Pradesh continue to lag significantly behind the year-ago pace. Industry sources again indicate that farmers are holding cotton in anticipation of higher prices. With the spread of cellular phones and mobile market information services, farmers are increasingly able to make more informed crop marketing decisions.

General Production Outlook: Cotton, a predominantly monsoon-season or kharif crop, is planted from the end of April through September, and harvested in the fall and winter. With the area under Bt cotton and improved varieties now reaching an estimated 92 percent of total area, prospects for future growth in productivity are limited as most cotton is grown under rain-fed conditions and on small farms. Researchers are working on production schemes with higher plant populations that could improve yields if they gain popularity with farmers. There are an estimated 5.5 million cotton farmers with the average farm size of 1.5 hectares which limits their ability to adopt capital intensive production technologies and infrastructure. However, yields would likely benefit from training in the management of irrigation, fertilizers, micro nutrients, pests and diseases to boost yields above current levels. Future growth in cotton production is more likely to come from higher yields than a significant area expansion.

India accounts for about a third of global cotton area. Within India, two-thirds of cotton is produced in the central cotton growing zone in the states of Maharashtra, Madhya Pradesh, Gujarat and Odisha where much of the crop is rain fed. The northern zone, which consists of the states of Punjab, Haryana and Rajasthan, produces cotton under irrigated conditions and accounts for about 15 percent of production. In the south, the states of Andhra Pradesh, Karnataka and Tamil Nadu account for 20 percent of production. The Central and Southern zones typically grow long duration cotton that allows farmers to reap multiple pickings or harvests. While the number of pickings has declined as traditional varieties have been replace by biotech hybrids, farmers can still extract up to five pickings per plant depending on weather conditions. In contrast, the irrigated cotton in the northern zone is mostly a short duration crop that fits into a cotton-wheat cropping system.

Bt cotton: Since its introduction in 2002, Bt cotton has been widely adopted and now accounts for an estimated 92 percent of total cotton area and over 95 percent of India’s cotton production. The Government of India has approved six biotech events and more than 300 hybrids for cultivation in different agro-climatic zones. In addition to the approved varieties, there are estimated 40-50 Bt cotton hybrids that are developed and multiplied informally outside of regulated marketing channels and sold at cheaper rates relative to approved hybrids. One of the results of the adoption of Bt cotton has been a significant shift in the varietal profile and share of different types of cotton being produced in India. Most of the Bt hybrids are of medium and long staple cotton (26 to 32 mm), which is resulting in declining production of short staple (below 22 mm) and extra long staple (35 mm and above). If the current trend continues, the domestic textile industry may seek to increasingly augment their extra long staple and short staple cotton requirements through imports.

Consumption:

MY 2013/14 consumption is forecast at a record 27.5 million 170 kg bales (21.5 million 480 lb bales/ 4.7 mmt). The textile industry continues to recover from the losses suffered during 2011/12. The industry has enjoyed strong spinning margins throughout much of 2012/13 and is on pace to export a record volume of yarn. Margins have started to narrow and the industry is calling on the Government of India to release the 2.0 million 170 kg bales that are currently held by CCI. Whether favorable spinning margins will persist in 2013/14 is difficult to determine. However, the industry is optimistic that textile demand in major western markets will strengthen in 2013/14 and, while India’s GDP growth has cooled of late, the economy continues to grow at an enviable rate of six percent, suggesting that domestic demand will at least remain firm. A weakened rupee, if it persists, will also be beneficial for yarn and textile exports. See the tables at the end of this report for additional information concerning textile production and cotton consumption.

Trade:

2013/14 exports are forecast at 7.5 million 170 kg bales (5.8 million 480 lb bales/1.3 mmt), down 15 percent from the revised 2012/13 estimate. China is again expected to be the key determiner of India’s export volumes. Exportable supplies of cotton are forecast to be adequate and exports to regional buyers like Pakistan and Bangladesh and Asian buyers like Vietnam and Indonesia are expected to average about 300,000 170 kg bales per month or 3.6 million 170 kg bales for the year. The degree to which exports exceed that level will depend on China. Currently, assuming that China will again be buyer of foreign cotton, albeit it at reduced levels, India’s exports to China are forecast at 4.0 million 170 kg bales. The rupee has consistently traded at Rs. 53-55 per dollar over the past six months which has helped to support export volumes. If the rupee strengthens, India’s price advantage in export markets could be curbed.

Exports for MY 2012/13 are estimated at 9.0 million 170 kg bales (7 million 480 lb bales/ 1.5 mmt), well above earlier expectations as strong demand from China, a weak rupee and competitive pricing spurred exports. Trade sources indicate that export shipments for 2012/13 had reached 7.8 million 170 kg bales (6.1 million 480 lb bales/1.3 mmt) through mid-March. China, Bangladesh, Pakistan and Vietnam are the biggest export markets for Indian cotton. With strong domestic demand, assumed weaker demand from China and a recent halving of the margin (from 8-9 cents per pound to 3-4 cents per pound) between Indian ex-gin prices and the Cotlook A index, the pace of exports is expected to slow through the balance of the August/July marketing year. Nevertheless, demand from regional and Asian buyers will likely lead to average monthly exports of 300,000 170 kg bales from April to July. Additionally, CCI may make a portion of the 2.0 million 170 kg bales it currently holds available to exports. Thus far, the higher than expected export pace has not prompted the textile industry to press for cotton export controls, instead the industry is actively encouraging the government to initiate the sale of CCI stocks in the domestic market.

India typically imports long staple cottons to augment domestic supplies for processing and re-export as high-end textiles. However, prior to the onset of the delayed 2012/13 harvest, mills imported larger volumes of cotton to augment general cotton supplies. Given the pace of exports and strong consumption thus far, mills could again be required to import larger volumes of cotton prior to the onset of the 2013 harvest. 2012/13 imports are estimated at 1.6 million 170 kg bales (1.2 million 480 lb bales/270,000 mt). For 2013/14, imports are estimated marginally lower at 1.0 million 480 lb bales /255,000 mt.

Policy:

As India has emerged as a cotton exporter in recent years, the Government of India has enacted a variety of trade policies to ensure that competitively-priced adequate supplies are available to the textile industry. India’s national fiber policy affirms that cotton exports should be limited to the exportable surplus. In March 2012, the Government of India enacted a ban on exports on account of the rapid pace of exports and the potential effect on domestic supplies of cotton. The ban was lifted in May of 2012 and replaced with a new export registration policy that enabled closer monitoring of exports. In October 2012, the Government of India announced the cotton export policy for MY 2012/13 (Oct/Sep). The policy was largely a continuation of the previous May 2012 policy. Cotton exports are allowed under Open General License subject to relatively strict export registration requirements, but are not currently subject to a quantitative limit or quota. For more information on India’s export policies see table 13.

Thus far, the textile industry has not pressed the government for export controls during 2012/13. Instead, the focus has been on releasing cotton from government-held stocks. While the export pace has exceeded expectations, it remains well below the record 2011/12 pace that prompted the government to briefly ban exports. Unless exports surge unexpectedly over the next few months, it seems unlikely that the textile industry will press for export controls. However, officials continue to monitor the pace of exports and could seek to tighten export registration requirements or deploy some other means of slowing exports if the pace continues to exceed expectations.

Cotton Advisory Board (CAB) Reconstituted: The CAB, which is comprised of inter-ministerial experts, meets regularly to estimate domestic cotton production, consumption and trade. The reconstituted CAB will now have a consultative committee that will give input to the Board. The consultative committee includes members from the textile industry and cotton trade. Both the consultative committee and the CAB are headed by the Textile Commissioner.

Production Policy

The Government of India establishes a minimum support price for cotton. New prices are typically announced annually and may or may not precede the start of planting. CCI, a central government organization, is responsible for price support operations in all states, but is occasionally assisted by other federal or state government marketing organizations. Government agencies purchase seed cotton at the MSP, and sell the processed cotton at market prices, and the losses incurred in the operation are borne by the government. In 2012\13, CCI procured 2.2 million 170 kg bales (1.7 million 480 lb bales/374,000 mt), of which 95 percent was from Andhra Pradesh to support farmers affected by tropical cyclone ‘Nilam’ in the first week of November. CCI was also involved in small procurement operations in the states of Maharashtra, Orissa, Karnataka and Madhya Pradesh but through most of the season, market prices have been above the MSP. Besides the MSP operations, CCI and state marketing organizations are also involved in purchasing cotton at open market prices for commercial sales. Purchases have been very limited thus far in 2012/13 amounting to 50,000 170 kg bales (39,040 480 lb bales /8,500 mt). See the production section for a discussion of the current MSP situation.

Various central and state government agencies and research institutions are engaged in cotton varietal development, seed distribution, crop surveillance, integrated pest management, extension and marketing activities. In 1999, the central government launched the Technology Mission on Cotton (TMC) to improve the availability of quality cotton at reasonable prices. The goal of the TMC is bring about improvement in the production, productivity and quality of cotton through research, transfer of technology and improvement in the marketing and raw cotton processing sectors.

Marketing:

India exports medium-to-long staple cotton (25 to 32 mm length) to China, Bangladesh and East Asian countries. However, India will likely continue to import ELS and quality long staple cotton (28-34 mm), with occasional imports of short staple cotton (below 22 mm) when international prices are favorable. The United States has been the leading supplier of cotton to India over the past few years. Indian mills importing U.S. Pima and upland cotton recognize its quality and consistency, and are ready to pay a premium over competing origins. However, U.S. cotton faces competition from suppliers like Egypt and Australia due to their freight advantage and shorter delivery periods. Due to warm weather conditions and tradition, cotton is typically the preferred fiber in India. However, poly-cotton blends are becoming increasingly popular due to their durability and ease of maintenance. Prices of cotton relative to man-made fibers will be key in determining the future growth of cotton usage in India.

Due to warm weather conditions and tradition, cotton is typically the preferred fiber in India. However, poly-cotton blends are becoming increasingly popular due to their durability and ease of maintenance. Industry sources report that higher cotton prices have caused some mills to shift their cotton/polyester blends in favor of polyester. Prices of cotton relative to man-made fibers (MMF) will be key in determining the future growth of cotton usage in India.

Value Added Cotton

The textile and clothing industry is largely cotton-based, accounting for 14 percent of total industrial production, 17 percent of total export earnings, four percent of GDP and providing direct employment to over 35 million people and indirect employment to an additional 55 million people. After agriculture, the textile industry is India’s largest employer. The “organized” or modern textile sector is dominated by spinning units which, in terms of numbers, account for 80 percent of the “units” in the modern industry. India’s textile industry would likely benefit from increased value addition in terms of weaving and garment manufacturing, but the industry continues to focus much of its effort on expansion of the spinning sector. The Indian textile industry includes both an "organized" sector (large-scale spinning units and composite mills) and an "unorganized" sector (small-scale spinning units, power looms, handlooms, hosiery units). More than 95 percent of yarn is produced in the organized sector. The weaving industry is mainly supplied by the unorganized sector, with power looms accounting for 63 percent, handlooms for 12 percent, and hosiery units for 21 percent of total cloth production. The organized sector weaving mills account for the remaining four percent of cloth production.

According to the Government of India, India ranks third in global exports of textiles and sixth in global exports of clothing with shares of 5.1 percent and 3.2 percent respectively. The United States and China are the top markets for textile exports with Bangladesh also emerging as a strong market. Cotton textile exports account for 50 percent of total textile exports. Cotton ready-made garments account for the major share of cotton textile exports followed by cotton yarn and cotton fabric. Cotton yarn exports have been on “Open General License” (not subject to quotas) since April of 2011. For additional information on textile exports and production see the tables at the end of this report.

In an effort to promote the export of value-added cotton textiles, the Government of India in its latest budget announcement for the upcoming 2013/14 fiscal year (Apr/Mar) has largely continued with major schemes to ensure affordable credit, technology improvement, skill development and duty relief to the textile sector. India’s current trade policy provides incentives to encourage textile exports such as favourable interest rates on pre-shipment credit, duty-free import of trimmings required by the garment industry and duty-free import of tools by the handicrafts industry. Firms with export oriented unit status and firms importing against an advance export license receive a duty drawback on imports of raw materials for the export of value-added goods. The Export Promotion Capital Goods plan, which enabled imports of capital goods and machinery at reduced duty rates against export obligations, will expire on March 31, 2013. Additionally, the Market Linked Focus Product Scheme, where exporters can earn credits valued at two percent of their exports to the United States and European Union, is also set to expire on March 31, 2013.

Debt Restructuring Package: To ease the financial distress from the global economic slowdown of the past few years and the losses from the market volatility during 2011, the government approved a debt restructuring package to aid textile mills. The program is administered on a case-by-case basis within parameters set by the Reserve Bank of India. Banks have extended the program to 307 textiles mills and 200 readymade garments factories.

The Technology Upgradation Fund Scheme (TUFS): TUFS has provided support for the modernization of the textile industry since 1999 through lower rates of interest on loans for the purchase of capital goods and improved technology. The Ministry of Textiles has proposed a budget of $442 million for the upcoming 2013/14 fiscal year (Apr/Mar).

Zero Excise Duty Route: The Government of India in its latest budget announcement for the upcoming 2013/14 fiscal year has cut the excise duty on ready garments made from cotton from 3.5 percent to zero.

Scheme for Integrated Textile Parks (SITP): SITP provides the textile industry with infrastructure facilities for setting up their textile units. SITP has created 61 new textile parks. The scheme is based on a public private partnership model where the Government of India share is restricted to 40 percent of the project cost or $7.3 million (Rs. 400 million) whichever is lower. An additional grant of $1.8 million (Rs. 100 million) will soon be available to each new project to assist firms in the apparel sector.

Scheme for Integrated Processing Development (IPD): IPD is a new scheme with an initial annual outlay of $92 million (Rs. 5 billion) to address the environmental concerns relating to effluent treatment.

Various Schemes for Handloom Sector: For the overall development of the handloom sector, the Government of India has taken various policy initiatives to sustain and develop the industry. The latest federal budget provides $17 million for FY 2013/14 (Apr/May) to make loans available at a reduced interest rate. This is in addition to two existing programs, the $710 million Comprehensive Handloom Package and the $430 million Revival, Reform and Restructuring Package.

State Textile Policies: The major cotton producing states of Gujarat and Maharashtra announced their textile policies in 2012, with several programs and schemes encouraging industries to locate their textile units in their respective states. The Gujarat Textile Policy will provide a five year interest subsidy on new plants, a power tariff concession for five years and a refund of the valued added tax on raw materials for new units and the expansion of existing units. The policy is aimed at bringing additional textile processing capacity closer to growers in India’s leading cotton producing state. Gujarat currently supplies a large volume of India’s cotton exports. In Maharashtra, similar interest subsidies are being provided on long-term loans for setting up new units. A significant volume of cotton is shipped out of Maharashtra to states where there is greater processing capacity; these measures are aimed at keeping cotton in the state and creating jobs. Over the next 5 years, some processing capacity may shift from the south (where about half of India’s cotton is processed) to the central states in view of the continuous power shortage problems faced by the industry in the south.

Extra Long Staple Cotton:

Table 1: Extra Long Staple (ELS) Cotton

India’s ELS production is forecast to decline slightly as farmers shift to higher yielding long and medium staple varieties. There are very few Indian cotton varieties (DCH-32, TCH-213, and Suvin grown mostly in southern India) that meet international ELS specifications. The fiber quality and yields of these varieties have deteriorated in recent years causing marketing problems and lower returns to growers. Therefore, farmers are increasingly shifting to long staple varieties (Bunny, Brahma, and other 30-34 mm cotton varieties), which have higher yields and fewer quality problems. Efforts to improve the productivity of ELS parent lines have met with limited success. There are some early efforts to develop biotech ELS varieties.

ELS cotton consumption is forecast marginally lower. India’s domestic consumption requirement for ELS cotton is largely met through imports and the United States and Egypt are the major suppliers. ELS cotton is used for the production of quality yarn, fabric, and dress material for a small but growing high-end domestic market segment and for export. Demand for luxury goods has fallen. Mills are still seeking ELS, but only for quantities equal to their orders. Local mills are increasingly using the long staple varieties for blending with imported ELS cotton for the production of quality yarn and fabric.

April 2013

DOWNLOAD REPORT:- Download this report here

Share This


Related Reports

Reports By Country

Reports By Category

Our Sponsors

Partners


Seasonal Picks

Country Dance